|
Register To Post |
Schrade | Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
HERE ... WE ... GO ... AGAIN ...
Common C4 failure - Power Seat Transmission / Track Failure. (while I contemplate Sill Trim...) Remove Seat CUSHION Base. Remove Seat from Track Assembly. |
||
Posted on: 2016/7/25 17:24
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Seat out. No goodies, no corner jam, save some dusts.
Access to Seat Mount bolts... |
||
Posted on: 2016/7/25 17:44
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Seat out, cleanup (ALWAYS BOLTS BACK IN HOLES, NUTS ON STUDS, ETC).
And Post Mortem, post eviction, should be VERY interesting here... |
||
Posted on: 2016/7/25 18:04
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Goodies sent by buyer...
|
||
Posted on: 2016/7/25 18:10
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Track / Tranny in.
Note Zip Tie to prevent chafing harness under seat. Dry run good, EXCEPT polarity for Forward Backward is REVERSED!!! Connector cleaned, DE Grease, KEYED, so NOT in backwards... ??? |
||
Posted on: 2016/7/25 18:25
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Anyone see anything wrong there?
So the Seat wasn't close to matching up Mount Bolts. Hmmm... And the Polarity is BACKWARDS. Hmmm................................ Are the assembly in backwards? ALWAYS WATCH ME WRENCH THE WRONG WAY HERE. Quote:
|
||
Posted on: 2016/7/25 18:39
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Wow; what a wrestling match WWE Survivor Series getting seat back onto Track Assembly.
It's obligatory that ONE bolt will cross-thread. Then you have to run THAT bolt into a good hole, AND IT GETS HOT, even greased. And run a GOOD bolt into the first hole. Monkey see, monkey do - HOT, but in correctly. In. Forward seat with Forward switch, imagine that, and REARWARD TOO, miracles don't stop ! 3 hours, 2 mixed drinks, 5 Chrome wrenches, one socket, one hammer, and a Solved. Post Mortem on OEM Track later... |
||
Posted on: 2016/7/25 20:02
Edited by Schrade on 2016/7/25 20:48:16 |
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
GOLDCYLON | Re: Power Seat Tranny Service; Track Swap... | ||
Guru Newb
|
What no lose change? I found $50 bill stuffed under there from PO when I pulled my drivers seat.
I bet the transmission is roached on the pulled unit. It never seems to be the motor. |
||
Posted on: 2016/7/25 20:11
|
|||
Transfer |
bogus | Re: Power Seat Tranny Service; Track Swap... | ||
Grand Imperial Pooh-Bah
|
I agree...
Inside the gearbox is a nylon support that holds all the gears. That breaks. Gears get eaten. Junk design, if you ask me. Looks like a nice job!!! |
||
Posted on: 2016/7/25 21:36
|
|||
_________________
The single biggest problem with communication is the illusion that it has taken place. - George Bernard Shaw Education is the best tool to overcome irrational fear. - me |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Any pics of breakdown there ANdy?
I think Darryl said you have to drill rivets to open it up? Quote:
|
||
Posted on: 2016/7/25 22:06
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
bogus | Re: Power Seat Tranny Service; Track Swap... | ||
Grand Imperial Pooh-Bah
|
I will check... don't have any with me now!
However... it is a ton of rivets... |
||
Posted on: 2016/7/26 1:07
|
|||
_________________
The single biggest problem with communication is the illusion that it has taken place. - George Bernard Shaw Education is the best tool to overcome irrational fear. - me |
|||
Transfer |
GOLDCYLON | Re: Power Seat Tranny Service; Track Swap... | ||
Guru Newb
|
IMHO destined to fail just like those handy pellets in the headlight mother however hard to complain about a 26 yo vehicle. Things do wear out with time and general wear. Well done Chuck
|
||
Posted on: 2016/7/26 4:09
|
|||
_________________
GOLDCYLON - 91 ZR-1 #2014 380 P&P&PCed,Ported Heads,Jeal headers,/Corsas/FIKSE FM-5s /LED TLs, HID Projectors,/R Baer Eradaspeed Rotors with Wilwood 6 piston front calipers |
|||
Transfer |
Schrade | Re: Power Seat Tranny Service; Track Swap... | ||
Elite Guru
|
Thanks! Couldn't (probably wouldn't have, till another time) without ya' there..........
Now, back to the sill trim here. Quote:
|
||
Posted on: 2016/7/26 15:58
|
|||
_________________
LT5, Marc Haibeck ECM module, AUTOMATIC!!! |
|||
Transfer |
You can view topic.
You cannot start a new topic.
You cannot reply to posts.
You cannot edit your posts.
You cannot delete your posts.
You cannot add new polls.
You cannot vote in polls.
You cannot attach files to posts.
You cannot post without approval.
|